Furnace Makeup Air Requirements

If an exhaust fan rated over 300 cfm is installed makeup air might be needed and a calculation will need to be done.

Furnace makeup air requirements.

Department of energy a defining feature of high efficiency furnaces is sealed combustion a process by which outdoor makeup air is piped directly into the burner. In addition our indoor outdoor direct fired make up air unit is an efficient way to supply tempered make up air to your space. Makeup air shall be mechanically or naturally provided makeup air systems shall be equipped with not less than one damper gravity dampers electrically operated damper that automatically opens when the exhaust system operates 26 2015 requirements adopted in pa. With a make up air unit that same 10 f air can be tempered to 50 f.

Likewise if the outside air temperature is 10 f then the ventilation fan is bringing in 10 f air. Several options are also available for the outdoor and indirect indoor make up air unit. The real requirement is that makeup air must be provided if it s needed. The minnesota mechanical code is a combination of chapters 2 to 15 of the 2006 international mechanical code and minnesota s amendments.

This means the heating system wouldn t be required to work any harder than is necessary nor would it waste energy. Our duct furnaces can be ordered with several different options so they fit your specific requirements. Such makeup air systems shall be equipped with a means of closure and shall be automatically controlled to start and operate simultaneously with the exhaust system. By glenn mathewson issue 287 kitchens baths.

Makeup air if you have a conventional furnace not high efficiency you can make a simple one by installing a dryer vent in the wall to outside about 2 1 2 ft above the floor pipe it to the area of the burners down into a 5 gallon bucket stopping about 5 inches above the bottom of the pail if your in a colder area insulate the pipe. According to the u s. Ten cubic feet of air contains 2 cubic feet of oxygen and 8 cubic feet of nitrogen and other gases combined with water vapor. Exhaust hood systems capable of exhausting in excess of 400 cfm 0 19 m 3 s shall be provided with makeup air at a rate approximately equal to the exhaust air rate.

Makeup air for kitchen exhaust. Of air per minute require makeup air so they don t depressurize the home and draw combustion gases from the appliance into the living space. A furnace must be supplied a specific amount of fresh air per cubic foot of gas burned.